活性白土的制備及對鉛鉻黃吸附性能的研究

摘要

本次實驗以云南曲靖鈣基膨潤土為原料，研究采用濕法制備活性白土的工藝；同時也對活性白土對鉛鉻黃的吸附性能研究進行了研究。

活性白土的制備的實驗過程中研究了硫酸與鹽酸的濃度、溫度、時間、硫酸與鹽酸組成的混酸體積比、酸固比對活性白土的主要性能指標的影響。研究結果表明活性白土的制備的最佳工藝條件：混酸體積比為1:1、酸固比4:1、活化溫度70℃、活化時間4h，可得到的活性度為211.3，脫色率為89.9%的高效活性白土。

活性白土對鉛鉻黃的吸附實驗過程中研究了活性白的使用量、吸附時間和吸附溫度對吸附效率的影響。研究結果表明鉛鉻黃吸附的最佳工藝條件：吸附溫度27℃、吸附時間50min、活性白土用量3.00g、對體積為50ml，濃度為0.2mg/L的鉛鉻黃模擬廢液吸附率達到99.10%。吸附后的鉛鉻黃廢液完全達到工業生產的排放標準。

關鍵字:膨潤土，活性白土，混酸改性，吸附，鉛鉻黃

ABSTRACT

In this experiment, Yunnan Qujing calcium bentonite as raw material, the activated clay prepared by wet process; but also on activated clay for lead chrome yellow Adsorption was studied. 

    Activated clay prepared experiment studied the concentration of sulfuric acid and hydrochloric acid, temperature, time, sulfuric acid and hydrochloric acid mixture consisting of the volume ratio of the acid activated clay solid ratio on the impact of key performance indicators. The results showed that the preparation of activated clay optimum conditions: mixed acid volume ratio of 1:1, 4:1 solid acid activation temperature 70℃, activation time 4h, the activity can be obtained 211.3 degrees, the decolorization rate was 89.9% efficient activated clay.

Lead chrome yellow activated clay adsorption experiments studied the use of the active white, adsorption time and adsorption temperature on the adsorption efficiency. The results showed that the adsorption of lead chrome yellow optimum conditions: adsorption temperature 27℃, adsorption time 50min, activated clay dosage 3.00g, on a volume of 50ml, the concentration of 0.2mg/L of lead chrome yellow simulated wastewater adsorption rate reached 99.10% . After adsorption of lead chrome yellow waste fully meet the emission standards of industrial production.

Keywords：Bentonite, activated clay, mixed acid modification, adsorption, lead chrome yellow

目 錄

摘  要 I

ABSTRACT II

1 緒論 1

1.1 膨潤土 1

1.2膨潤土的用途 1

1.3 課題背景 2

1.4活性白土 3

1.5活性白土制備機理 3

1.6活性白土的生產工藝 4

1.7 活性白土的用途 5

1.7.1 植物油的凈化 5

1.7.2催化劑 6

1.7.3無碳復寫紙生產 6

1.7.4環保 6

1.7.5其他方面 6

1.8活性白土研究現狀及發展趨勢 6

1.9鉛鉻黃 7

1.9.1鉛鉻黃的用途 7

1.9.2鉛鉻黃工業污染的形成 8

1.9.3活性白土對鉛鉻黃的吸附機理和研究方法 8

2 實驗研究 9

2.1實驗儀器和藥品 9

2.1.1實驗儀器設備 9

2.1.1實驗藥品 9

2.2 實驗方案 9

2.3 實驗步驟 10

2.3.1 H2SO4制備活性白土 10

2.3.2 HCl制備活性白土 11

2.3.3混酸制備活性白土 11

2.3.4活性白土對鉛鉻黃的吸附 12

2.4產品的檢測方法 12

2.4.1活性白土的分類、型號和代號 12

2.4.2 活性白土的性能參數 12

2.4.3活性度的檢測 13

2.4.4 脫色率的檢測 13

3 實驗結果分析 15

3.1單一酸制備活性白土 15

3.1.1 H2SO4制備活性白土 15

3.1.2 HCl制備活性白土 16

3.2混酸制備活性白土 17

3.2.1混酸體積比對活性白土性能的影響 17

3.2.2酸固比對活性白土性能的影響 18

3.2.3活化溫度對活性白土性能的影響 19

3.2.4活化時間對活性白土性能的影響 20

3.2.5混酸制備活性白土小結 21

3.3活性白土對鉛鉻黃的吸附 21

3.3.1鉛鉻黃標準溶液的吸光度曲線繪制 21

3.3.2活性白土用量對吸附效率的影響 22

3.3.3吸附溫度對吸附效率的影響 22

3.3.4吸附時間對吸附效率的影響 23

3.3.5鉛鉻黃吸附實驗小結 23

3.4不同酸化劑制備活性白土的IR分析 23

4 結論及展望 25

參考文獻 26

致 謝 28